Product ID:JEFFCO 3142 (HARDENER COMPONENT)
MSDS Date:06/02/1992
FSC:8040
NIIN:00N057401
MSDS Number: BWQPQ

JEFFCO PRODUCTS

5252 KEARNY VILLA WAY
SAN DIEGO, CA 92123
US

Emergency Phone: 619-576-990;800-424-9300(CHEMTREC)

Info Phone: 619-576-990

Cage: JEFFC

JEFFCO PRODUCTS

SAN DIEGO, CA 92123 US

Telephone: 619-576-9900

Cage: JEFFC

1,2-ETHANEDIAMINE, N-(2-AMINOETHYL-)-N'-(2-((2-AMINOETHYL)

CAS: 112-57-2

RTECS: KH8585000

Fraction By Weight: <05%

OSHA PEL N/K

ACGIH TLV: N/K

BENZYL ALCOHOL

CAS: 100-51-6

RTECS: DN3150000

Fraction By Weight: <45%

OSHA PEL N/K

ACGIH TLV: N/K

AFTER DECONTAMINATION. NO SPECIFIC ANTIDOTE.

RTECS: 9999999ZZ

RESPONSE TO REACTIONS OF THE PATIENT.

RTECS: 9999999ZZ

IF VAPOR EXPOSURE CAUSES EYE IRRIT, USE A

RTECS: 9999999ZZ

SHOULD BE LOCATED IN IMMEDIATE WORK AREA.

RTECS: 9999999ZZ

SUCH AS GLOVES ,BOOTS, APRON, OR FULL-BODY

RTECS: 9999999ZZ

LD50 LC50 Mixture:LD50: (ORAL,RAT) >2140 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYE: MAY CAUSE SEV IRRIT W/CORNEAL
INJURY, WHICH MAY RSLT IN PERM IMPAIRMENT OF VISION, EVEN
BLINDNESS. VAPS MAY IRRIT EYES. SKIN: MAY CAUSE SEVERE INJURY TO
SKIN FOLLOWING PLNGD/RPTD CONTACT & MAY CA USE SKIN SENSIT/OTHER
ALLERGIC RESPONSES. SKIN(ABSORP): A SINGLE PLNGD EXPOS MAY RSLT IN
MATL BEING (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: ABSORBED IN HARMFUL AMTS. INGEST:
SINGLE DOSE ORAL TOXICITY IS LOW. INGEST MAY CAUSE GI IRRIT/ULCER.
INGEST MAY CAUSE BURNS TO MOUTH & THROAT. INHAL: MAY CAUSE RESP
SENSIT/ASTHMA IN SUSCEPTI BLE INDIVIDUALS. EXCESS EXPOS MAY
CAUSEIRRIT TO UPPER RESP TRACT. RPTD EXCESS EXPOS MAY CAUSE LIVER &
KIDNEY (SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:EYES: IMMED & CONTINUOUS IRRIGATION W/FLOWING WATER FOR AT
LEAST 30 MINUTES REQD. PROMPTLY SEEK MED ATTN. SKIN: IMMED FLUSH
SKIN W/PLENTY OF WATER FOR AT LEAST 15 MINS WHILE REMOVING CONTAMD
CLTHG, PR EF UNDER A SAFETY SHOWER. SEEK MED ATTNIMMED. AVOID
PLNGD/RPTD CONT TO SKIN. INGEST: DO NOT INDUCE VOMITING. GIVE LGE
AMTS OF WATER/MILK IF AVAIL & TRANSPORT TO MED FACILITY. INHAL:
REMOVE (SUPDAT)

Flash Point Method:PMCC
Flash Point:>210F,>99C
Extinguishing Media:WATER FOG, ALCOHOL FOAM, CO*2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:USE A POSITIVE PRESSURE, NIOSH/MSHA
APPROVED SCBA.

Spill Release Procedures:LGE SPILL: DIKE UP & PUMP INTO APPROP CNTNRS.
SMALL SPILL: USE NONCOMBUSTIBLE ABSORBENT MATL/SAND & SHOVEL INTO
SUITABLE CNTNRS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:GROUND ALL TRANSFER EQUIPMENT. HOLD
BULK STORAGE UNDER A NITROGEN BLANKET. THIS PRODUCT SHOULD NOT COME
IN CONTACT W/COPPER/COPPER-BEARING ALLOYS.
Other Precautions:REMOVE CONTAMINATED CLOTHING IMMEDIATELY. WASH SKIN
AREA W/SOAP & WATER & LAUNDER CLTHG BEFORE REUSE. CONTAMINATED
LEATHER ITEMS, SUCH AS SHOES, BELTS & WATCHBANDS, SHOULD BE REMOVED
& DESTROYED.

Respiratory Protection:ATMOSPHERIC LEVELS SHOULD BE MAINTAINED BELOW
THE EXPOSURE GUIDELINE. WHEN RESPIRATORY PROTECTION IS REQUIRED FOR
CERTAIN OPERATIONS, USE A NIOSH/MSHA APPROVED AIR-PURIFYING
RESPIRATOR.
Ventilation:CONTROL AIRBORNE CONC BELOW EXPOS GUIDELINE. USE ONLY
W/ADEQ VENT. LOCAL EXHST VENT MAY BE NEC FOR SOME OPERATIONS.
Protective Gloves:IMPERVIOUS GLOVES
Eye Protection:ANSI APPRVD CHEM GOGGS. (ING 5)
Other Protective Equipment:ANSI APPRVD SAFETY SHOWER AND EMER EYE WASH
SHOULD BE LOCATED IN IMMED WORK AREA. SELECTION OF SPECIFIC ITEMS
(ING 7)
Work Hygienic Practices:GOOD GENERAL HOUSEKEEPING PROCEDURE SHOULD BE
FOLLOWED.
Supplemental Safety and Health
EFTS OF OVEREXP: EFFECTS. RESULT IF IN VITRO("TEST TUBE") MUTAGENICITY
TESTS HAVE BEEN NEGATIVE. FIRST AID PROC: TO FRESH AIR IF EFTS
OCCURS. CONSULT MD. NOTE TO MD: CORR. MAY CAUSE STRICTURE. IF LAVA
GE IS PERFORMED, SUGGEST ENDOTRACHEAL &/ESOPHAGOSCOPIC CONTROL. IF
BURN IS PRESENT, TREAT AS ANY THERMAL BURN (ING 3)

Boiling Pt:B.P. Text:DECOMPOSES
Vapor Pres:13 @ 130F
Spec Gravity:1.06
Solubility in Water:SLIGHTLY SOLUBLE
Appearance and Odor:AMBER COLORED LIQUID W/AMINE ODOR.

Stability Indicator/Materials to Avoid:YES
EXPOXY RESINS UNDER UNCONTROLLED CONDITIONS.
Stability Condition to Avoid:CAN AUTOIGNITE IN AIR AT APPROXIMATELY
572F.
Hazardous Decomposition Products:NITROGEN OXIDES WHEN BURNED.

Waste Disposal Methods:LGE QUANTITIES SHOULD BE RECOVERED. COLLECT
SMALL QUANTITIES IN WASTE METAL DRUMS & SEAL FOR REMOVAL TO AN
APPRVD LANDFILL/INCINERATE IN ACCORDANCE WITH LOCAL, STATE &
FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.